In order to make the generator set serve everyone better, users should pay attention to some use problems in the process of use. However, in the whole use process, some users still ignore some problems. For example, some users add too much oil when using. Today, I briefly introduced the problem of oil use. I hope it can be helpful to you!

一、油太多會導致什么問題

1、 What's the problem with too much oil

1.點火問題。您可能聽說過發電機組的點火。造成這個問題的原因之一是柴油機油太多。由于機油過多導致柴油機油位升高，在曲軸負載下很容易造成燃氣混合。當發電機組的工作溫度升高時，它將著火并點燃，甚至可能導致曲軸箱出現一些緊急使用問題。

1. Ignition problem. You may have heard of the ignition of a generator set. One of the reasons for this problem is too much diesel oil. Because the oil level of diesel engine rises due to too much oil, it is easy to cause gas mixing under crankshaft load. When the working temperature of the generator set rises, it will catch fire and ignite, which may even lead to some emergency use problems of the crankcase.

2.提高油耗。發電機組的供油量與汽油量不同。發電機組柴油機充油過多時，發電機組發動機曲軸左右端容易漏出多余的柴油，造成柴油機的消耗和環境污染，這將增加柴油機維修的難度系數。

2. Improve fuel consumption. The oil supply of the generator set is different from that of gasoline. When the diesel engine of the generator set is overfilled, the left and right ends of the engine crankshaft of the generator set are easy to leak excess diesel, resulting in diesel engine consumption and environmental pollution, which will increase the difficulty coefficient of diesel engine maintenance.

二、正確的供油方法

2、 Correct oil supply method

1.打開發電機的油蓋。里面有一個濾網。將濾網放置到位。先倒入柴油，然后給柴油機加油（注意必須處于滿油狀態，否則會有氣體，以后無法正常啟動）。

1. Open the oil cover of the generator set. There is a filter screen inside. Put the screen in place. First pour in diesel oil, and then refuel the diesel engine (note that it must be full of oil, otherwise there will be gas, and it will not start normally in the future).

2.將設備放置到位，打開柴油蓋。油箱位于控制面板下方，有一個可擰在發動機缸體上的外蓋。打開油蓋后，滴油（敲黑板，滴油時放在這里，不能傾斜，斜加會造成氣缸密封，設備不會發出聲音）。當油滿了，它被加到瓶塞上，瓶塞會流出來，也不會流出來，只要想想身體和人的眼睛就能看到油。

2. Place the equipment in place and open the diesel cover. The tank is located under the control panel and has an outer cover that can be screwed to the engine block. After opening the oil cover, drop the oil (knock on the blackboard and put it here when dropping the oil. It cannot be tilted. The oblique addition will cause the cylinder seal and the equipment will not make a sound). When the oil is full, it is added to the cork. The cork will flow out and will not flow out. Just think about the body and human eyes to see the oil.

三、關于石油供應的常見問題

3、 Frequently asked questions about oil supply

1.柴油機質量管理。加油時不要拆下汽油和柴油濾網，以免浮塵、污漬或其他外部污垢滲入柴油機。如果柴油機內充滿不干凈的東西，會損壞柴油機過濾機和設備，增加柴油機噴油嘴和油泵系統的損壞，對發電機的使用壽命有直接或間接的危害。

1. Diesel engine quality management. Do not remove the gasoline and diesel filter screen during refueling to avoid floating dust, stains or other external dirt penetrating into the diesel engine. If the diesel engine is filled with unclean things, it will damage the diesel filter and equipment, increase the damage of diesel fuel injection nozzle and oil pump system, and do direct or indirect harm to the service life of Yuchai generator set.

2.以適當的方式加油。用戶在供油時應隨時觀察和檢查油表，不得使汽油、柴油溢出或泄漏到柴油機和消聲器上。如果發生意外溢出或泄漏，可在啟動發電機前清潔柴油機。

2. Add oil in an appropriate way. The user shall observe and check the oil gauge at any time when supplying oil, and shall not overflow or leak gasoline and diesel to the diesel engine and muffler. In case of accidental spillage or leakage, clean the diesel engine before starting the generator set.

3.供油時間控制。只有在關閉汽油和柴油閥門并冷卻發電機組后，才能向發電機組供油。廠家建議發電機組在整個運行過程中無需供油，因為在運行過程中供油時，機油很容易飛濺出來，存在風險。從長遠來看，它還會危及發電機組的使用壽命。

3. Oil supply time control. Only after closing the gasoline and diesel valves and cooling the generator set can oil be supplied to the generator set. The manufacturer suggests that the generator set does not need oil supply during the whole operation, because the oil is easy to splash out during the operation, which is risky. In the long run, it will also endanger the service life of the generator set.